1994 - 2002
|
|
|
|
Range Rover P38A Series 2 Cooling & Heating System
1994 - 2002 |
|
Page Contents
Cooling System Additive ©Rimmer Bros Ltd - Registered in England No. 2155394. VAT No. GB 352 8473 40.
Water Pump
Viscous Coupling
Drive Belts
Radiator
Pressure Cap
Intercooler - Diesel
Oil Cooler - Engine
Thermostat
Radiator Hoses
Hose Clips
Heater Components
Heater Pipes/Hoses
Air Conditioning Components
Antifreeze
Radiator Relief
Water Pump;
Diesel - (1) - STC3342
V8 - 4.0/4.6 Litre - (1) - STC4378
Seal - water pump - diesel - (1) - STC2189
Gasket - water pump - V8 - (1) - ERR4077
Viscous Coupling;
Diesel - complete with fan - (1) - PGG101290
V8 - less fan - (1) - ERR4996
Drive Belt - ancillary (inc water pump);
V8 - serpentine belt
Up to VIN WA410481 (1998)
With Air Con - (1) - ERR4460
Without Air Con - (1) - ERR4461
VIN XA410482 (1999) on
With Air Con - (1) - PQS101480
Without Air Con - (1) - PQS101640
Diesel - (1) - STC4455
Tensioner - serpentine belt;
V8 - (1) - ERR6439
Diesel - (1) - STC4168
Radiator;
V8 - 4.0/4.6 Litre Models
Up to WA (1998) - (1) - PCC106940
VIN XA (1999) on - (1) - PCC106850
Diesel
Auto - (1) - PCC108470
Manual - (1) - PCC108460
Drain Plug - radiator - V8 - (1) - ERR4686
Seal - drain plug - V8 - (1) - ERR4685
Bush - oil cooler to radiator - (2) - EJP1483
Petrol & diesel.
Pressure Cap - expansion tank - (1) - PCD000070
All models.
Intercooler - diesel;
Standard - (1) - ESR2504
Uprated - (1) - RA1466
Suitable for models up to 2002. Requires powerbox.
20/30% power increase. Please refer to Accessories section for Powerbox details.
Modifications required to mounting brackets.
Intercooler Hoses;
Intercooler to Inlet Manifold
Non EGR Vehicles - (1) - ESR3289
EGR Vehicles - (1) - ESR4122
Intercooler to Turbo
Up to VIN VA (1997) - (1) - ESR3290
3-part hose supplied with clips.
VIN WA (1998) on - (1) - PNH101710
Clip - intercooler hoses - 60mm - (ar) - PYC102340
Engine Oil Cooler;
V8
4.0 Litre - (1) - ESR3204
4.6 Litre - (1) - ESR3205
Diesel - (1) - PBC101420
Thermostat (complete with housing);
The thermostat/housing assembly on V8s is located in the bottom radiator hose.
V8 - (1) - PEM101130
Diesel - (1) - STC3338
Gasket - thermostat - diesel - (1) - STC2194
Top Hose - radiator;
V8 - 4.0/4.6 Litre
Up to VIN WA (1998) - (1) - PCH114840
VIN XA (1999) on - (1) - PCH000900
Diesel
Up to VIN WA403803 (1998) - (1) - PCH116950
Non EGR.
VIN WA803804 to VIN XA - (1) - PCH124730
EGR.
VIN YA (2000) on - (1) - PCH124730
EGR.
Bottom Hoses - radiator - V8 (4.0/4.6 litre);
Pump to Thermostat - (1) - PEH101590
Thermostat to Radiator - (1) - PCH118820
Heater to Thermostat
Up to VIN WA (1998) - (1) - PEH101520
VIN XA (1999) on - (1) - PCH000910
Bypass Pipe to Thermostat - (1) - PEH101510
Bottom Hose - radiator - diesel - (1) - PCH124720
Bypass Pipe (rigid);
V8 - 4.0/4.6 Litre - (1) - ESR3193
Hose Clips
Radiator Hoses
60mm - (ar) - PYC102340
50mm - (ar) - GHC10417
30mm - (ar) - GHC10415
Heater Hoses - (ar) - AWR2725
Heater Assembly & Components
For price & availability of complete heater assemblies and heater components not listed, please contact our sales department.
Heavac Control Unit (heat & A/C);
Mounted in centre console.
Models with Heated Seats - (1) - JFC102550
Models without Heated Seats - (1) - JFC102540
Matrix - heater - (1) - STC3261
Temperature Sensor - heater - (1) - STC3256
Motor - flap control - heater - (1) - STC3259
Pollen Filter - (2) - BTR8037
Heater Hose (flexible);
V8 - 4.0/4.6 Litre
Inlet Manifold to Heater - (1) - JHB100920
Heater Return - (1) - PCH118830
Expansion Tank - (1) - JHC100420
Diesel
Engine to Heater Valve - (1) - PCH124740
Heater Inlet - (1) - PCH000030
Heater Return - (1) - PCH124750
Heater Pipe (rigid) - diesel - (1) - AWR2690
Listed below are the principal air conditioning components.
If the part you require is not listed, please contact our sales department.
Please remember to have details of your VIN/chassis number to hand.
Heavac Control Unit (heat & A/C);
Mounted in centre console.
Models with Heated Seats - (1) - JFC102550
Models without Heated Seats - (1) - JFC102540
Compressor;
Diesel - (1) - ERR4375
V8
Up to VIN WA410481 (1998) - (1) - ERR4534
VIN XA410482 (1999) on - (1) - JPB101330
Drive Belt - air con - diesel - (1) - STC3397
Drive Belt - A/C + Ancillaries - V8;
Up to VIN WA410481 (1998) - (1) - ERR4460
VIN XA410482 (1999) on - (1) - PQS101480
Condenser - (1) - STC3679
Receiver/Dryer - (1) - AWR1374
Pressure Switch - on/off - (1) - BTR9223
Tri-Pressure Switch - (1) - JTB100370
Evaporator - (1) - STC3260
Expansion Valve - evaporator - (1) - JQD100340
Sensors - air conditioning;
Temperature Sensor - evaporator - (1) - STC3365
Temperature Sensor - in car - (1) - JTF000030
Solar Sensor - (1) - BTR9733
Ambient Sensor;
Located on blower motor up to VIN WA381430 and behind front bumper from WA381431 on.
Up to VIN WA381430 (1998) - (1) - STC3257
VIN WA381431 on - (1) - JTF100270
Switch Cover Kit - (1) - JTN100020
Set of replacement switch covers for the automatic climate control unit.
Antifreeze - all engines;
1 Litre - (1) - GAC2018
5 Litres - (1) - GAC2019
Radiator relief allows your radiator to transfer heat more efficiently, reducing your engines operating temperature (which is obviously controlled by the thermostat) by up to 30°F.
You therefore have 'a little bit in hand' for those hot days stuck in traffic.
This proven coolant additive will also cut engine warm-up time in half which will reduce engine wear which is most extreme when the engine is cold.
Fully compatible with water and anti-freeze and is safe with cast iron and all alloys.
• 30°F lower operating temperature
• 50% quicker warm up time
• Safe with water/antifreeze mixture
• Safe with cast iron, alloy engines and heads
• Increased engine life!
• 100% biodegradable, non corrosive, non toxic
• For use in all water cooled engines
Radiator Relief (946ml) - (ar) - RX1461
Treats 1 engine.
Return to Range Rover P38 Index Page 
Home About Rimmer Bros. Prices General Info Delivery How to Order Your Order Form News Restoration Projects Picture Library Triumph Links Free Catalogue Contact Us
The 'Triumph', 'Rover' and 'British Motor Heritage' Logos used herein are Registered Trade Marks of British Motor Heritage Ltd,
and are used with their Licence under the Special 'Heritage' approval Scheme.
All original part numbers & illustrations have been reproduced by kind permission of British Motor Heritage.