Page Contents
Engine Electrics - Major Units
Engine Electrics - Ignition System
Starter Motor Immobiliser
Headlamp & Fittings
Front, Side & Flasher Lamps
Rear Lamps & Fittings
Rear Number Plate Lamp
Fog Lights
Windscreen Wiper/Washer System
Instruments
Speedo Cables
Switches/Controls
Switch Knobs
Relays, Fuses & Horns
Radio Aerial
Battery & Fittings
Wiring Harness
Engine Electrics - Major Units
Alternator - Dynamo - Starter
Lucas,original manufacturer of the majority of electrical equipment on British cars, have a system which up-dates all their equipment continuously. Therefore, units repaired or replaced over previous years, have more than likely been updated and consequently parts listed below may not be suitable unless full notice of the information listed is taken.
Dynamo - TR4/4A
Lucas Type 22700/22704/22715 - (1) - GXE3101
Brush Set for Dynamo - (1) - GGB102
Bearing - dynamo front - (1) - 529221A
Bush - dynamo rear - (1) - 7H5390
Fan - dynamo - (1) - 147333
Pulley - dynamo - (1) - 102266
Alternator - TR5/250
Lucas 15ACR (less fan and pulley) - (1) - GXE8211
Brush Set for Alternator - (1) - GGB504
Bearing - alternator front - (1) - 529221A
Fan - alternator - (1) - AAU3956A
Pulley - alternator - (1) - AEU1238
Control Box - Dynamo Charge;
TR4/4A - (1) - GEU6605
Control Unit - Alternator Charge;
TR4A5/250 - (1) - BHA4789
Starter Motor - TR4/4A
Inertia Type (standard) - (1) - GEU4412R
Original Lucas Starter were Model Type M418G.
Later replacements were of Model 2M100 Type (check type if spares required).
Uprated Hi-Torque Starter - (1) - GEU4412UR
Brush Set;
M418G - TR4/4A original - (2) - GSB103
2M100 - TR4/4A original - (2) - GSB108
Pinion/Sleeve Assembly - (1) - 503529
Spring/Main - (1) - 7H5007
Brush - starter front plate - (1) - 244714A
Bush - starter rear plate - (1) - 242958A
Shim - starter to plate adj. - (ar) - 104549
Starter Motor - TR250
Inertia Type (standard) - (1) - GEU9405
Lucas Type: 25022 or 25079.
Uprated Hi-Torque Starter - (1) - GEU9405UR
Brush Set - (1) - GSB102
Pinion & Barrel;
Starter 25022 - (1) - 67H5010
Starter 25079 - (1) - 67H5010
Solenoid (remote type) - (1) - 134174
Bush - drive end;
Starter 25022 - (1) - 7H5049
Starter 25079 - (1) - 47H5346
Bush - commutator end;
Starter 25022 - (1) - 511141
Starter 25079 - (1) - 47H5340
Starter Motor - TR5
Pre Engaged Type (standard) - (1) - GXE4439
Lucas Type: 25626 or 25647.
Uprated Hi-Torque Starter - (1) - GXE4439UR
Brush Set;
Starter 25626 - (2) - GSB103
Starter 25647 - (2) - GSB108
Pinion & Barrel Assembly;
Starter 25626 - (1) - 517462
Starter 25647 - (1) - 520457
Solenoid;
Starter 25626 - (1) - AEU1649
Starter 25647 - (1) - 520473
Bush Kit - front & rear - (1) - TCB116
Engine Electrics - Ignition System
Distributor
Distributor (exchange);
TR4/4A (83mm engine) - (1) - 208643R
TR4/4A (86mm engine) - (1) - 208972R
TR5 - (1) - 214459R
TR250 - (1) - 308460R
Distributor Cap;
TR4/4A - (1) - GDC114
TR5/250 - (1) - GDC115
Rotor Arm;
TR4/4A - (1) - GRA101
TR5/250 - (1) - GRA102
Condenser - all models - (1) - GSC111
Contact Breaker Points - (1) - GCS101
All models.
Screw - contact breaker points - (1) - 511842
All models.
Low Tension Lead;
TR4/4A (DM2P4 type) - (1) - 600329A
TR5/250 (25D4 type) - (1) - 600329A
Plugs, Leads & Coil
Spark Plug;
TR4/4A
Standard - (4) - GSP4366
High Performance - (4) - GSP4366HP
TR5/250
Standard - (6) - GSP4362
High Performance - (6) - GSP6462
Plug Lead Set;
TR4/4A (top entry) - (1) - RF4099
TR4/4A (top entry)(silicone) - (1) - RF4099S
TR4/4A (side entry) - (1) - HMP221001
TR5/250 - (1) - GHT142
TR5/250 (silicone) - (1) - GHT142S
Ignition Coil;
All models. Push in lead type.
Standard - (1) - GCL110
Lucas - (1) - GCL110LUCAS
High Performance - (1) - GCL110HP
Electronic Ignition Kit;
Newtronic
TR4 (positive earth) - (1) - RF4101POSITIVE
TR4A/5/250 - (1) - RF4101
Lumenition
TR5/250 - (1) - RR1113
Lumenition Magnetronic
TR5/250 - (1) - RR1432
Lumenition Performance Kit
Includes sports coil.
TR5/250 - (1) - RR1113PERFORMANCE
Starter Motor Immobiliser
'Dis-Car-Nect' starter immobiliser - (ar) - RX1356
Replacement screw knob - (ar) - RX1356KNOB
Replacement fuse - (ar) - RX1356FUSE
How Does 'Dis-Car-Nect' Work?
When leaving your car, simply remove the knob to isolate the starter circuit. The 16amp by-pass fuse will maintain current to all other electrical circuits - stereo memories, alarm etc. Because the starter motor draws over 150amps, any attempt to connect (hot-wire) the starter motor will instantly cause the by-pass fuse to blow, this immobilises the car until the knob is replaced. If this should happen, simply replace the 16amp fuse at your convenience. As an added advantage, the 'Dis-Car-Nect' will also prevent battery drain if you intend to store your car, simply unscrew the knob and remove the fuse. For extra security you can unscrew and remove the immobiliser knob completely.
|
|
Headlamp & Fittings
TR4 Light Unit (only);
RHD - (2) - GLU501
LHD - (2) - GLU513
TR4 Tripod Type Light Unit (only);
RHD - (2) - 501713
LHD - (2) - 500999
TR4/4A Sealed Beam Unit;
RHD - (2) - GLU132
LHD - (2) - GLU513
TR5/250 Sealed Beam Unit;
RHD - (2) - GLU132
LHD - (2) - GLU133
Halogen Conversion Kit;
2 light units, 2 bulbs and connectors. Easily fitted kit.
Available with or without pilot (side) light.
RHD
No Pilot - (1) - RB7129
With Pilot - (1) - RB7129PILOT
LHD
No Pilot - (1) - RB7082
With Pilot - (1) - RB7082PILOT
Chrome Mesh Headlamp Stoneguard (pair) - (1) - RR1175
TR4 Headlamp Bulbs;
For original headlamps.
RHD - (2) - GLB414
LHD - (2) - GLB415
LHD France (yellow) - (2) - GLB411
Headlamp Outer Rim (chrome) - (2) - 119072
Light Unit Retaining Rim - (2) - 515218A
Headlamp Backing Bowl - (2) - S5400
Headlamp Backing Adjuster Kit - (2) - BHM7058
Headlamp to Body Gasket - (2) - 9403
Harness for Sealed Beam Headlamp - (2) - BAU2110
Front, Side & Flasher Lamps
TR4
Side Lamp Assembly - (2) - 514805
Lens & Rim Only - (2) - 510897
Bulb Only for 514805 - (2) - GLB233
Flasher Lamp Assembly - (2) - 121356
Lens -flasher only - (2) - 37H5520
Rim - flasher lens only - (2) - 7H5182
Bulb only for 121356 - (2) - GLB382
TR4A/5
Side/Repeater Lamp Assembly;
Complete ready to fit.
RH - (1) - 212486
LH - (1) - 212488
Side Lamp (front) only - (2) - 514805
Lens (clear) Rim only for 514805 - (2) - 510897
Bulb only for 514805 - (2) - GLB233
Lens Side only (amber) - (2) - 616648
Bulb only (repeater) - (2) - GLB501
Flasher Lamp Assembly (remote) - (2) - 121356
Lens only for 121356 - (2) - 37H5520
Rim only for 121356 - (2) - 7H5182
Bulb only for 121356 - (2) - GLB382
TR250
Side/Repeater Lamp Assembly
Use TR4A/TR5 212486 or 212488 and fit Amber Lens version of 510897 to convert to USA Spec.
Other parts as TR4A/TR5.
Flasher Lamp Assembly (remote) - (2) - BHA4477
Lens only for BHA4477 - (2) - 517266
Bulb only for BHA4477 - (2) - GLB382
Side Marker Lamp Assembly (rear) - (2) - 142923
Bulb only for 142923 - (2) - GLB504
Rear Lamps & Fittings
Rear Lamp Assembly Complete;
All Models - (2) - 208208
All Models (USA only) - (2) - 208207
Lamp Lens only;
All Models - (2) - 516040
All Models (USA only) - (2) - 516061
Flasher Bulb - all models - (2) - GLB382
Stop/Tail Bulb - all models - (2) - GLB380
Rubber Gasket;
Lens to Lamp - (2) - 510906
Lamp to Body - (2) - 133364
Rear Number Plate Lamp
All Models
Number Plate Lamp Assembly - (2) - UKC7274
Chrome Outer Cowl Only - (2) - 131465
Lamp Lens Only - (2) - 510875
Bulb Only - (2) - GLB207
Fog Lights
Front Fog Light (pair) - (1) - RX1370
Rear Fog Light (each) - (2) - RB7092
Windscreen Wiper/Washer System
Windscreen Wiper Motor DR2 type;
TR4 (less drive gear) - (1) - 514821R
To body No. 7783CT - RHD.
Tp body No. 30CT - LHD.
Windscreen Wiper Motor DR3A type;
TR4 (less drive gear) - (1) - GXE7714
To body No. 7783CT - RHD.
To body No. 30CT - LHD.
Windscreen Wiper Motor DR3 type;
TR4A/5/250 (less drive gear) - (1) - 514821
Wiper Motor Gear only;
Early TR4 - (1) - 520939
Later TR4/4A/5/250 - (1) - 511078
Wiper Drive Cable - all models - (1) - RTC202A
Cut to fit.
Wiper Wheelbox (inc nut) - (2) - 37H6316
All models.
Wiper Box Fitting Kit - (2) - 37H6316FK
Wheelbox Nut Only - (2) - RF4100
Wiper Box Surround inc washer jets (pair) - (1) - 519919
Wiper Box Surround only - (1) - 511070-1
No jets (pair).
Washer Jet - (2) - 112740
Wiper Arms;
RHD - all models
RH - (1) - 131105
LH - (1) - 131106
LHD - all models.
RH - (1) - 131107
LH - (1) - 131108
Wiper Blades;
TR4/4A - Silver - (2) - GWB219
TR5/250
Silver - (2) - GWB118
Black - (2) - GWB711
Blades Refill - all models - (1) - GWR102
Pair.
Windscreen Washer Bottle Assembly;
Complete unit including bracket.
TR4/4A (inc manual pump) - (1) - RF4096
Replacement type.
TR4/4A (inc electric pump) - (1) - RF4096
Glass bottle type.
TR5/250 (inc electric pump) - (1) - 215822
Original type (square).
TR5/250 (inc electric pump) - (1) - 215822ALT
Alternative type (rectangular).
Bottle Only - TR4/4A;
Plastic (manual pump) - (1) - 609172
Glass - (1) - 553757
Bottle Only - TR5/250;
Original type (square) - (1) - 518264B
Bracket & Strap only - TR5/250 - (1) - 518265
Motor & Cap only - TR5/250 - (1) - GWW111
Washer Tubing Kit - (1) - GWW411K
Includes tubing, T piece and grommet.
Washer Tubing (per metre) - (ar) - GWW202M
Instruments
A bewildering range of various speedometer heads were original equipment on TR4/4A models using flat or domed glass facia's and calibrated to suit varying axle ratio's, type equipment and then KPH or MPH. It would be pointless to try to offer a complete range of exchange units off the shelf therefore, a repair and recon service is available for speedo's and rev counters for these models. We are however, able to offer limited availability for TR5 & TR250.
TR4 (early) Speedos (domed type glass);
3.7 Axle X ply Tyres
RHD - MPH - (1) - 208062R
LHD - KPH - (1) - 208063R
4.1 Axle X Ply Tyres
RHD - MPH - (1) - 208066R
LHD - KPH - (1) - 208067R
3.7 Axle Radial Tyres
RHD - MPH - (1) - 208655R
LHD - KPH - (1) - 208656R
4.1 Axle Radial Tyres
RHD - MPH - (1) - 208657R
LHD - KPH - (1) - 208658R
TR4 (late)/TR4A Speedos (flat type glass);
3.7 Axle X Ply Tyres
RHD - MPH - (1) - 209182R
LHD - KPH - (1) - 209183R
4.1 Axle X Ply Tyres
RHD - MPH - (1) - 209184R
LHD - KPH - (1) - 209185R
3.7 Axle Radial Tyres
RHD - MPH - (1) - 209188R
LHD - KPH - (1) - 209189R
4.1 Axle Radial Tyres
RHD - MPH - (1) - 209186R
LHD - KPH - (1) - 209187R
TR5/250 Speedos;
TR5 - SN6409/06 - MPH - (1) - 214427R
TR5 - SN6409/07 - KPH - (1) - 214428R
TR250 - SN6409/10 - MPH - (1) - 214431R
TR250 - SN6409/11 - KPH - (1) - 214432R
Rev Counters;
TR4 (early) Domed Glass - (1) - 208090R
TR4 (late)/4A Flat Glass - (1) - 209194R
TR5/250 - (1) - 214263R
Fuel Gauge;
TR4 (early) Domed Glass - (1) - 130539R
TR4 (late)/4A Flat Glass - (1) - 133118R
TR5/250 - (1) - 147961R
Water Temp Gauge;
Domed Glass
TR4 (early)(Fahrenheit) - (1) - 131060R
TR4 (early)(Centigrade) - (1) - 131061R
Flat Glass
TR4 (early)(Fahrenheit) - (1) - 133124R
TR4 (early)(Centigrade) - (1) - 133119R
TR4A (late) - (1) - 145594R
TR5/250 - (1) - 147963R
Oil Pressure Gauge;
Domed Glass
TR4 (early)(lbs) - (1) - 106966R
TR4 (early)(kg) - (1) - 110896R
Flat Glass
TR4 (late)/TR4A (lbs) - (1) - 133120R
TR4 (late)/TR4A (kg) - (1) - 113121R
TR5/250 - (1) - 147960R
Ammeter;
Domed Glass
TR4 (early) - (1) - 125111R
TR4 (late)/TR4A - (1) - 133117R
TR5/250 - (1) - 147962R
Voltage Stabilizer;
TR4/4A - (1) - 128484
TR5/250 - (1) - 148876A
Temp Transmitter;
TR4/4A - (1) - GTR104
TR5/250 - (1) - GTR108
Speedo Cables
Speedo Cable;
TR4/4A - RHD - Non O/D (78") - (1) - GSD141
TR4/4A - LHD - Non O/D (69") - (1) - GSD169
TR4/4A - RHD/LHD - with O/D (69") - (1) - GSD169
TR5/250 - RHD/LHD (69") - (1) - GSD169
Rev Counter Cable;
TR4/4A - all models - RHD - (1) - GSD111
TR4/4A - all models - LHD - (1) - 504619
TR5 PI - RHD - (1) - 144370
TR5 PI - LHD - (1) - UKC2873
TR250 - LHD - (1) - 138316
Switches/Controls
Indicator Stalk - all models - (1) - 158966
Side Headlight Switch - TR4 - (1) - 131812
Side/Headlamp Stalk - all models;
RHD - (1) - 142579
LHD - (1) - 159358
Overdrive Stalk (column);
RHD - (1) - 147280
LHD - (1) - 147281
Wash Wiper Switch;
TR4 - (1) - 2H4841
TR4 - (1) - 1H9077
TR5/250 - (1) - 148410
Windscreen Washer Switch;
TR5/250 - (1) - 158452
Ignition Switch Less Barrel;
All Models - (1) - 127651
Barrel & Keys Only - (1) - 24G1345
Steering Column Lock/Switch - (1) - 2190611
When fitted.
Panel Light Rheostat Switch - (1) - TKC3936
All models.
Hazard Warning Switch;
TR5/250 - (1) - 156044
Heater Blower Switch;
TR4/4A - (1) - 2H4841
TR5/250 - (1) - 131812
Voltage Stabilizer;
TR4/4A - (1) - 128484
TR5/250 - (1) - 148876A
Brake Light Switch;
TR4 - (1) - 126845
TR4A/5/250 - (1) - 134529
Reverse Light Switch - (1) - BAU1074A
Gearbox O/D/ Inhibitor Switch - (ar) - BAU1074A
Door Courtesy Switch - TR5/250 - (2) - 627748
Glove Box Lamp Switch - (1) - 619071
Foot Operated Dip Switch - (1) - RTC432A
Oil Pressure Switch - TR5/250 - (1) - GPS117
Temperature Transmitter;
TR4/4A - (1) - GTR104
TR5/250 - (1) - GTR108
Switch Knobs
Dash Knob Set;
TR4/4A (includes items marked * below) - (1) - RF4049
TR5/250 (includes items marked + below) - (1) - RF4050
Light Switch Knob - TR4 * - (1) - 704885
Panel Light Knob
TR4/4A * - (1) - 704879
TR5/250 + - (1) - 621726
Windscreen Wiper Knob - TR4/4A * - (1) - 704875
Heater Switch Knob - TR4/4A * - (1) - 704883
Heater Knob - TR4/4A * - (1) - 704884
Air Control Knob - TR4/4A * - (1) - 704881
Choke Cable Knob - TR4/4A * - (1) - 704873
Heater Switch Knob - TR5/250 + - (1) - 712911
Heater Knob - TR5/250 + - (1) - 712903
Air Control Knob - TR5/250 + - (1) - 712909
Choke Cable Knob - TR5/250 + - (1) - 712907
Relays, Fuses & Horns
Horn (replacement type);
High Note - (1) - GGE164
Low Note - (1) - GGE165
Air Horns (pair) - (1) - RX1381HELLA
Flasher Unit;
TR4/4A - (1) - GFU103
TR5/250 - (1) - GFU2124
Horn Relay;
TR4/4A - (1) - 1377471
TR5/250 - (1) - 142169
Overdrive Relay - (1) - 142169
All models.
Hazard;
TR5/250 Relay - (1) - 148643
TR5/250 Flasher Unit - (1) - C28520
Ignition Relay - TR5/250 - (1) - 142169
Fusebox Assembly;
TR4/4A - (1) - 606253A
TR5/250 - (1) - RTC440A
Fusebox Cover Only;
TR4/4A - (1) - 505158A
TR5/250 - (1) - RTC440ACOVER
Fuses (packs of 5);
5 Amp - (ar) - GFS3005
10 Amp - (ar) - GFS3010
15 Amp - (ar) - GFS3015
20 Amp - (ar) - GFS3020
25Amp - (ar) - GFS3025
35 Amp - (ar) - GFS3035
50Amp - (ar) - GFS3050
Control Box;
TR4/4A Dynamo - (1) - GEU6603
TR4/4A Alternator - (1) - GEU6609
TR5/250 (4 terminals) - (1) - BHA4789
TR5/250 (3 terminal) - (1) - GEU6609
Radio Aerial
Radio Aerial - (1) - AJM1112
Extension Lead - (1) - ZKC533
Battery & Fittings
Battery (wet charged) - (1) - GBY5606
Not available mail order.
Battery Bracket Fixing Kit - (1) - RB7165
Battery Box Tray - (1) - RR1184
Battery Seating Pad - (1) - 613155
Battery Charger - (1) - GAC7106
Battery Conditioner - (1) - RX1410
Automatic on/off charger - see accessories.
Battery Lead & Clamp;
TR4 (positive earth)
Battery to Earth - (1) - 131113
Battery to Solenoid - (1) - 131115
TR4A (negative earth)
Battery to Earth - (1) - 142590
Battery to Solenoid - (1) - 142591
TR4/4A/250
Solenoid to Starter - (1) - 131114
Engine to Chassis (earth) - (1) - 131116
TR5
Positive to Starter - (1) - 517081
TR250
Positive to Starter - (1) - 142591
TR5/250
Negative to Earth - (1) - 516508
Wiring Harness
Wiring Harness;
RHD - to CT14913 - (1) - 305321
RHD - from CT14914 - (1) - 305610
LHD - to CT9983 - (1) - 305281
LHD - from CT9984 to CT26999 - (1) - 305611
LHD - from CT2700 on - (1) - 306645
TR4A
RHD - (1) - 307235
LHD - (1) - 307234
TR5
RHD (full harness) - (1) - RF4097
LHD (main harness) - (1) - 308496
LHD (body harness) - (1) - 214910
TR250
LHD (full harness) - (1) - RF4098
Overdrive Harness;
On Gearbox - (1) - 131339
Gearbox to Column - (1) - 148696
Scotchlok Connector - (ar) - RX1419
General use.
Return to TR4 / TR5 Index Page 
Home About Rimmer Bros. Prices General Info Delivery How to Order Your Order Form
News Restoration Projects Picture Library Triumph Links Free Catalogue Contact Us
©Rimmer Bros Ltd - Registered in England No. 2155394. VAT No. GB 352 8473 40.
The 'Triumph', 'Rover' and 'British Motor Heritage' Logos used herein are Registered Trade Marks of British Motor Heritage Ltd,
and are used with their Licence under the Special 'Heritage' approval Scheme.
All original part numbers & illustrations have been reproduced by kind permission of British Motor Heritage.
